Thread: Need help 04' R-12x not charging
11-14-2009, 02:40 PM #1
Need help 04' R-12x not charging
I looking at a friends 04' R-12 x 2 seater honda, I just put a new battery in it, and it runs fine, but the alarm, and batt light comes on.
I put a volt meter on the battery while running, and is at 11.9v while revving engine up.
I checked the fuses in the back near the battery, all are good.
I checked the connection at the rectifier, and cleaned them/blew out. Still not charging.
Any thoughts as to why it dosen't have any output?
Where should I look next?
Thanks in advance, Jason
11-14-2009, 05:00 PM #2
i bet there's an ohm chek of the stator at the regulator connector or something in the service manual. I can look when i get back from boston on friday.
11-14-2009, 06:51 PM #3
That would be great. I would love to do some tests, before guessing on any of the charging system parts, and waisting money.
11-15-2009, 04:46 PM #4
11-16-2009, 07:47 PM #5
11-17-2009, 06:14 AM #6
while you're waiting there is a green wire for ground on the back of the block.. look under the boost pipe from turbo to IC. And repost on pwctoday honda forum..more guys have manuals over there.
11-17-2009, 09:41 PM #7repost on pwctoday honda forum
11-19-2009, 05:29 PM #8
11-19-2009, 09:29 PM #9
Check the voltage at the battery while running @5000 RPM. Should be 15.5 v
if not..Next Put a oscilloscope on the positive Batt cable and record the amp charge or draw (should be under 2amp draw)
if not ohm out the rectifier.
1) green wires ..should show ground
2) yellow to yellow .1-1 ohm
3) red/white tracer and ground wire 12Vdc
That how I troubleshoot them and It works.
Post your results.
11-19-2009, 09:40 PM #10
Users Browsing this Thread
There are currently 1 users browsing this thread. (0 members and 1 guests)
By rcwsound in forum Honda How To & FAQsReplies: 8Last Post: 08-08-2008, 06:58 AM
By g2teg4 in forum Honda Open DiscussionReplies: 24Last Post: 12-23-2007, 01:50 PM
By Searey in forum Honda How To & FAQsReplies: 2Last Post: 11-20-2007, 01:32 PM
By Alexsphoto in forum Honda Open DiscussionReplies: 1Last Post: 08-22-2007, 08:11 PM
By Hondaid in forum Honda Open DiscussionReplies: 12Last Post: 07-27-2007, 12:31 PM