07-05-2010, 11:39 PM #1
100 hour service, please advise...
I brought the skis home from the lake where we keep them since they have 114 hours each on them. They are a 2004 RXP and 2005 RXT. Both run perfect. Besides the following can you think of anything else I should inspect and/or replace?
- SC rebuilt by Jerry
- Replace carbon ring (both are fine but I figure since the SC's will be out I should replace them)
- Inspect impeller and flip wear rings
- Oil change
- New plugs
Anything else I should do?
07-06-2010, 07:04 PM #2
07-06-2010, 09:15 PM #3
haha, nope. Is there anything else I should be checking besides the stuff I listed?
07-06-2010, 09:19 PM #4
You might want to consider checking the pump bearings for excessive play, and replace the pump seals... both front & rear.
07-06-2010, 09:47 PM #5
yeah, replace all the valves. mine went at 111 hrs. everything else was fine.
07-07-2010, 02:50 AM #6
07-07-2010, 08:09 AM #7
Have the wear rings ever been replaced or are they original? I would just buy new ones, they aren't that expensive.
07-08-2010, 09:08 PM #8
07-09-2010, 04:53 AM #9
Re: 100 Hour Service
Pull your batteries and check the electrolyte levels!!! Bring level to upper mark with distilled water if needed.
07-11-2010, 01:11 PM #10
Users Browsing this Thread
There are currently 1 users browsing this thread. (0 members and 1 guests)
By Mccoy in forum 4-Tec PerformanceReplies: 5Last Post: 03-06-2008, 04:24 PM
By ADAMBOMB in forum 4-Tec PerformanceReplies: 15Last Post: 02-15-2008, 08:52 AM
By skooter525 in forum Sea Doo Open DiscussionReplies: 14Last Post: 05-18-2007, 12:12 PM
By RX951 in forum Yamaha PWC Performance (2-stroke)Replies: 8Last Post: 12-25-2006, 11:12 AM
By GeoRXT in forum Sea Doo Open DiscussionReplies: 8Last Post: 06-15-2006, 04:27 PM