Page 1 of 2 1 2 LastLast
Results 1 to 10 of 20
  1. #1

    04 gtx Boggs And Chokes..With oil warning

    Ok so i just did a fresh supercharger rebuild and thought that would be the problem but it wasn't.

    when i give the ski full throttle the rpm goes right up but the ski boggs and wont go over 40-50mph.

    and when i give it slow throttle its beeps, the oil light comes on and just stops.

    i checked the coils, plugs and it all seems to be ok.

    that could be the problem here?


  2. #2

  3. #3
    Did you have a supercharger failure?

  4. #4
    Quote Originally Posted by 8 is enough View Post
    Did you have a supercharger failure?
    I thought it was the supercharger, but when i pulled the sc out all the washers were still there. I did a complete rebuild anyways hoping that would be the problem, and it wasnt.

  5. #5
    Having Fun jp1300r's Avatar
    Join Date
    Sep 2005
    Location
    Florida
    Posts
    5,334
    +1
    261
    Is it going in to limp mode? Did you check the spark plugs or just replace them? Replace them because you can't tell, if they are good or bad by looking at them. You going to have to figured out the oil warning problem.

  6. #6
    Quote Originally Posted by jp1300r View Post
    Is it going in to limp mode? Did you check the spark plugs or just replace them? Replace them because you can't tell, if they are good or bad by looking at them. You going to have to figured out the oil warning problem.
    When i give it full throttle the rpm goes way up to 6-7kand will slowly climb up to 45mph, but when i give it slow throttle it goes to like 3k rpm and goes into limp mode and a long beep with the oil warning.

  7. #7
    Boost addict hotbird's Avatar
    Join Date
    Jul 2011
    Location
    Southern WI
    Posts
    5,503
    +1
    681
    Check over your tops system make sure the tops valve opens (clicks) when you put the key on.

    If that's not it I would try to hook a mechanical gauge to the oil pressure port and see if you have proper oil pressure.

    You may just need 1 or both oil pressure sensors. they are known to go out on the early skis like this one.

    It sounds like your going into limp mode after the oil warning goes on.

    Also check the oil level make sure its full but NOT OVER FILLED!

  8. #8
    Tiny's Avatar
    Join Date
    Sep 2006
    Location
    The Atl
    Posts
    3,561
    +1
    578
    Oil pressure regulator

  9. #9
    SplishSplash's Avatar
    Join Date
    May 2006
    Location
    Belle River Ont Canada
    Posts
    1,184
    +1
    98
    The rpms going up but acceleration being slow points to a possible pump issue. I had one do exactly that and it was a rock wedged in the impeller chewing up the wear ring. It would start and idle fine (other than a bit morenoise from the pump). When the rpms go up, the wear ring sticks to the rock in impeller and the engine overloaded and died.

    Worth a look.

    Doubt its that, but won't hurt to check.

  10. #10
    Quote Originally Posted by hotbird View Post
    Check over your tops system make sure the tops valve opens (clicks) when you put the key on.

    If that's not it I would try to hook a mechanical gauge to the oil pressure port and see if you have proper oil pressure.

    You may just need 1 or both oil pressure sensors. they are known to go out on the early skis like this one.

    It sounds like your going into limp mode after the oil warning goes on.

    Also check the oil level make sure its full but NOT OVER FILLED!

    Where are the pressure regulators located and are they easy to replace?

    thanks for all the help guys..

Page 1 of 2 1 2 LastLast

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Similar Threads

  1. 04 GTX performance and opinions?
    By basscat250 in forum 4-Tec Performance
    Replies: 3
    Last Post: 06-07-2015, 08:26 AM
  2. FS 1200 pv stator and cover with oil block off
    By JIM'S PERFORMANCE in forum Yamaha Classifieds
    Replies: 10
    Last Post: 09-11-2012, 04:29 PM
  3. New and need help with 04 GTX SC
    By daveGTX in forum 4-Tec Performance
    Replies: 8
    Last Post: 08-30-2010, 08:40 PM
  4. Cover olate for oil fill and choke
    By OsideBill in forum Yamaha PWC Performance (2-stroke)
    Replies: 8
    Last Post: 01-11-2007, 11:54 PM
  5. oil warning and a long beep
    By daverxp4 in forum 4-Tec Performance
    Replies: 4
    Last Post: 08-14-2006, 03:25 PM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •