Results 1 to 2 of 2
  1. #1
    TangoDown's Avatar
    Join Date
    Nov 2012

    '04 RXP Oil false oil warning light

    Hey GH,

    I recently purchased an '04 RXP 215.

    Just to make this clear, the oil is at the proper level using this procedure. Run the ski for 5 minutes around at low speeds 3k-5k RPM, the come in, make it level and check oil level. The oil is 3/4 up the dip stick.

    However, the oil warning light comes on occasionally when I am out riding and goes into limp mode until I turn it off. It immediately goes away on start up. There are no stored codes either.

    The light comes on almost 100% of the time if I slowly lift off the throttle and reach the 3000 RPM mark and still decelerating. If I slow down and never make it to 3k before accelerating again, it is fine. Or if I am coming off idle speed and slow accelerating to the 3k mark, it will come on then also. But if I go WOT from a stop, it does not come on at all...

    I know that this year ski are prone to having oil level sensors go bad, particularly the top sensor and am hopping that is the only problem.

    How difficult is it to change the lower sensor?

    Thank you for any and all help!


  2. #2
    Having Fun jp1300r's Avatar
    Join Date
    Sep 2005
    They have oil pressure sensors not oil level sensors. Maybe a sensor or you really do have low oil pressure. You can try replacing sensors, but I would check oil pressure, too. There is a time delay on the oil pressure warning thats why you can go WOT from a stop, but when you lift off it throws a warning once it drops below 3K and a certain oil pressure.

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Similar Threads

  1. Oil warning Light 05 RXP
    By junglist519 in forum 4-Tec Performance
    Replies: 3
    Last Post: 09-04-2009, 12:16 PM
  2. Oil Warning Light came on... oil level was fine.
    By smbstyle in forum Yamaha PWC Performance (2-stroke)
    Replies: 12
    Last Post: 07-26-2009, 07:34 PM
  3. FX HO oil warning light coming on if I stop and start fast..
    By xRXPMike in forum Yamaha PWC Performance (4-stroke)
    Replies: 7
    Last Post: 09-27-2008, 09:09 AM
  4. OIL warning light
    By Daz RXT in forum 4-Tec Performance
    Replies: 14
    Last Post: 02-27-2008, 12:06 PM
  5. why did my RXP barf out oil?...
    By DANNYA09 in forum 4-Tec Performance
    Replies: 11
    Last Post: 07-03-2006, 11:45 AM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts