Results 1 to 7 of 7
  1. #1
    thetolleyman's Avatar
    Join Date
    Jul 2010
    Location
    Williamsburg, VA
    Posts
    562
    +1
    2

    2002 XP, where does the "cooling system drain hose" go.

    I just replaced the engine in an 02' XP. The engine and a few parts were already removed and dissembled when I got the ski, so....There is a 3/8" hose connector on the right side crankcase, about 10" below the main water inlet. I'm pretty sure it had a clear hose on it, but it was not connected to anything when I got the ski.


    Where does this go? I see no open fitting on the rear of the hull or on the exhaust system.


    Thanks


  2. #2
    SURFnTURF's Avatar
    Join Date
    May 2007
    Location
    Australia
    Posts
    878
    +1
    11
    Have a look here as its easier to give you the link than type it again

    http://www.pwctoday.com/showthread.p...03#post3630003

  3. #3

    Join Date
    Aug 2012
    Location
    Garland, Tx
    Posts
    256
    +1
    12
    you might need to get the water circuit diagram of a shop manual.. (they are free to download on the internet, just google.. )

    when i had pulled my motor, i actually had to come back, and blow compressed air through the lines to figure out which on was which..

    .. if its the line i think you are describing, that comes off the side of the block, that line should go to the air ocmpressor silencer, which if you blow air through it, should come out of the thru-hull fitting at the back of the ski..

  4. #4
    SURFnTURF's Avatar
    Join Date
    May 2007
    Location
    Australia
    Posts
    878
    +1
    11
    Quote Originally Posted by Jetman150 View Post
    you might need to get the water circuit diagram of a shop manual.. (they are free to download on the internet, just google.. )

    when i had pulled my motor, i actually had to come back, and blow compressed air through the lines to figure out which on was which..

    .. if its the line i think you are describing, that comes off the side of the block, that line should go to the air ocmpressor silencer, which if you blow air through it, should come out of the thru-hull fitting at the back of the ski..
    02 XP are carb model,Dis started on the xp in 03

  5. #5
    thetolleyman's Avatar
    Join Date
    Jul 2010
    Location
    Williamsburg, VA
    Posts
    562
    +1
    2
    I've got the manual, it doesn't show the specific location.

    Anyway, I found it, its very hidden below the exhaust hose, steering cable and other junk on the transom.

    Thanks to all.

  6. #6

    Join Date
    May 2013
    Location
    fargo nd
    Posts
    108
    +1
    1
    i had the same problem, used the parts house diagramto figureit out. this was on the right hand side near the bottom of the jet pump, right?

  7. #7
    thetolleyman's Avatar
    Join Date
    Jul 2010
    Location
    Williamsburg, VA
    Posts
    562
    +1
    2
    Yep!

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Similar Threads

  1. Replies: 1
    Last Post: 10-09-2012, 07:03 AM
  2. Polaris SL900 - Where does the throttle/oil pump/choke cables go?
    By koryk in forum Polaris Open Discussion
    Replies: 2
    Last Post: 05-23-2010, 09:29 PM
  3. Where does the power come from 215 ---> 255?
    By Spanners in forum 4-Tec Performance
    Replies: 14
    Last Post: 01-07-2010, 02:57 AM
  4. where does the AFR gauga hook up at?
    By stevorxp007 in forum 4-Tec Performance
    Replies: 21
    Last Post: 11-25-2009, 09:22 PM
  5. Where Does The Oil Go?
    By RATMAN in forum 4-Tec Performance
    Replies: 2
    Last Post: 02-24-2007, 09:56 PM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •