Thread: WTB: 96 SL780 Fuel Sender
05-07-2008, 03:05 AM #1
WTB: 96 SL780 Fuel Sender
The fuel level on the MFD is showign empty even with a full tank. I am in need of a new fuel sending unit if anyone has one.
Also, if anyone has any other suggestions, please pm ASAP! Thanks guys!
05-07-2008, 05:37 AM #2
05-07-2008, 06:03 AM #3
05-07-2008, 12:37 PM #4
I think I can handle tha. However, few questions.
1. Is this the float in the picture? Or does the float come with this kit from Randy?
2. Does anyone have any pictures or instructions of the install. I havent ever take out the sending unit before and I am a little worried that once I get it out, it will never seal right again. Any suggestions on how to properly seal the tank once the float is replaced?
05-07-2008, 01:47 PM #5
05-07-2008, 02:22 PM #6
Sweet! What about replacing the gasket? does one come with the kit or can I substitute the gasket for a silicon type material.
05-07-2008, 02:31 PM #7
No need to replace the gasket unless it leaks, I don't think I've ever replaced one yet.
Worst case scenario you might have to loosen the tank and bring it forward so you can pull the sender out.
IF your wires run all the way into the electrical box, just cut the wires near the sender unit and install a weather pack connector.
05-07-2008, 10:03 PM #8
i have a very nice, low hr 96 SL780 here, we started parting last fall. i think it should still have the sender in it if you do need the complete assy.
let me know if i can help at all. ( please send me an email).
my bad, this was a 96 SLX 780. probably the same sender though. i KNOW i have a good SL750 one too.
Last edited by john zigler; 05-07-2008 at 10:10 PM.
05-08-2008, 03:09 AM #9
Thanks guys for the help. I will pull the sender as soon as I get the chance and do the float in the gas test. Hopefully all I have to order is the float from Randy.
Anyone know if he gives discounts to GH members?
05-19-2008, 09:48 PM #10
- Join Date
- May 2008
- St Paul, Mn
Users Browsing this Thread
There are currently 1 users browsing this thread. (0 members and 1 guests)
By garyg25 in forum Polaris How To & FAQsReplies: 3Last Post: 05-21-2012, 09:38 AM
By jcc011185 in forum Polaris PWC PerformanceReplies: 12Last Post: 11-03-2011, 08:07 AM
By dorf in forum Polaris How To & FAQsReplies: 0Last Post: 09-07-2010, 08:45 AM
By andy95'slx780 in forum Polaris ClassifiedsReplies: 2Last Post: 09-27-2008, 05:36 PM
By andy95'slx780 in forum Polaris PWC PerformanceReplies: 2Last Post: 10-01-2006, 02:39 PM