Results 1 to 7 of 7
  1. #1
    crownline99's Avatar
    Join Date
    Jan 2009
    Location
    Buffalo, NY
    Posts
    37

    Unhappy 2002 1200 xlt won't start

    So I just finished removing the CAT, the oil pump, and installing powervalve clips. Mixed up my first tank of 40:1 premix, and was ready to run it on the hose with a fully charged battery. Go to start it and....nothing. No clicks, no noise.. All connections were reattached, and new plugs installed.

    I'm going to start by testing the starter relay with a multimeter, coils, etc in the electronics box.

    I'm severely bummed as the weather is finally nice, and this is my first waverunner.

    Anyone have a starter relay or whole electronics box for sale (cdi not required..I hope)??


  2. #2

    Join Date
    Jul 2008
    Location
    cape cod
    Posts
    195
    check out the classified section, lots of stuff there for sale

  3. #3
    crownline99's Avatar
    Join Date
    Jan 2009
    Location
    Buffalo, NY
    Posts
    37
    Already did and have a few PM's to sellers. Continuity test proved that the starter relay is dead. Anyone selling electrical box, or better yet just the relay?

  4. #4
    Kid In A Adult Body sandman7793's Avatar
    Join Date
    May 2009
    Location
    Naples, FL
    Posts
    63
    Did you check to make sure after you put the exhaust back in u plugged in the water temp sensor and the new chip because it wont do nothing unless there in

  5. #5
    crownline99's Avatar
    Join Date
    Jan 2009
    Location
    Buffalo, NY
    Posts
    37
    The water temp sensor is plugged in and the oil level sensor zip tied up. I do have a chip I never used...maybe I'll plug it in to test..

  6. #6
    crashhard's Avatar
    Join Date
    Jul 2007
    Location
    Philly PA, Wildwood NJ, Indialantic FL
    Posts
    2,382
    +1
    24
    if not sent you a pm on the complete box, will ship tomorrow

  7. #7
    zx11rider's Avatar
    Join Date
    Jun 2009
    Location
    Cape Coral
    Posts
    1,132
    I thought i had a fully charged battery as well because it was 4 months old and on a battery tender, Do your self a favor and take it to the auto parts store and let them test it, mine was bad so i bought an oddesy battery and it started right up. good luck with it

Thread Information

Users Browsing this Thread

There are currently 1 users browsing this thread. (0 members and 1 guests)

Similar Threads

  1. 2002 Gensis I won't start
    By Makon in forum Polaris PWC Performance
    Replies: 0
    Last Post: 09-03-2011, 05:00 PM
  2. 2002 Virage TXI won't Start or Runs rough when Damp
    By cjohnson in forum Polaris Open Discussion
    Replies: 16
    Last Post: 07-11-2011, 11:18 PM
  3. 2002 Virage TX won't start unless battery is 100% or on charger!
    By ggrande in forum Polaris Open Discussion
    Replies: 3
    Last Post: 07-05-2010, 09:43 PM
  4. 2002 Genesis i won't start when cold or 'cool'
    By K447 in forum Polaris Open Discussion
    Replies: 13
    Last Post: 12-10-2009, 03:12 PM
  5. 2002 GTX DI won't start
    By GTXDI in forum 2-Stroke Performance
    Replies: 6
    Last Post: 08-03-2009, 01:10 AM

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •