GPR fuel flapper removal...........

[WATER WOODY]

Pretty basic, remove fuel pick-up from tank to access fuel flapper.

There it is.


The fuel doors tend to warp over time and if they are stuck closed,your fuel supply will greatly reduced,causing a serious bog.

[WATER WOODY]

.

[RX951]

very self explanatory, thanks Wood-Dawg !

[Hydrotoys]

Here is a picture of a warped one to illustrate.

[OsideBill]

I have found that it is easier to remove the unit from the tank if you disconnect the steering cable from the arm.

[stingray152003]

whats the point of that flapper?

[spaceman]

stop fuel from running out of the pipe, when u jump waves.

[K447]

whats the point of that flapper?

stop fuel from running out of the pipe, when you jump waves.

If the flapper is going bad, what are the symptoms when riding?

[HallPass]

sorry, so is that fuel flapper is like what is on top of the gas tank, with the tubes going off it going to like the main,reserve,vent, etc?

how do you take it off/out?

[Duke]

sorry, so is that fuel flapper is like what is on top of the gas tank, with the tubes going off it going to like the main,reserve,vent, etc?

how do you take it off/out?

Reread post 1 and 2.

[HallPass]

it's been re-read... so how do you take it off do you just like pull it off?

[Duke]

it's been re-read... so how do you take it off do you just like pull it off?

Picture 1 shows the pickup in his hand. Hint-its out of the gas tank now!

Picture 2 shows Kevin unscrewing the #2 philips head screw.

Picture 3, 4, and 5 show the screen and the flapper door

Picture 6 shows Kevin putting the screen back in without the flapper door!

Picture 7 shows putting the screw back in

Picture 8 shows the piece you throw in the garbage!!!!

WTF Kale!! I even got my 16 year old daughter to look at the pics before i responded to see if she understood, thinking it might be a teenager thing. She said she was blonde not retarded!!

[HallPass]

lol duke.. i wasnt asking how to take off the fuel flap. That is a bolt I know.. I have brown hair....

I was asking how to take off the whole thing.. like the whole piece, so I could then access my fuel flap door to take it off

[OsideBill]

Picture 1 shows the pickup in his hand. Hint-its out of the gas tank now!

Picture 2 shows Kevin unscrewing the #2 philips head screw.

Picture 3, 4, and 5 show the screen and the flapper door

Picture 6 shows Kevin putting the screen back in without the flapper door!

Picture 7 shows putting the screw back in

Picture 8 shows the piece you throw in the garbage!!!!

WTF Kale!! I even got my 16 year old daughter to look at the pics before i responded to see if she understood, thinking it might be a teenager thing. She said she was blonde not retarded!!

now this is priceless

[ZMANN]

loosen the hose clamp and slide it up then just pull up it's a little tight but it's just a rubber seal Z